Recycling Trains

  • Although recycling train cars is good for the environment, Buffalo’s transit authority is also doing it to save some money. (Photo courtesy of the US Department of Transportation)

Some cities are trying to save some money by recycling trains. They’re renovating and re-using their old mass-transit rail cars. Joyce Kryszak went to find out just how you go about recycling a train:

Transcript

Some cities are trying to save some money by recycling trains. They’re renovating and re-using their old mass-transit rail cars. Joyce Kryszak went to find out just how you go about recycling a train.

It’s hard to say whether there are more roads or train tracks running through the small town of Hornell, New York– a couple of hours southeast of Buffalo. The acres and acres of tracks of the old Erie Railroad yards are here. And for more than 150 years, Hornell has repaired trains in its shops. But recently, it’s started completely rebuilding some passenger rail cars.

We crouch underneath one of the jacked-up 40 ton cars and Mike Bykowski shows us how.

“This is car 114, it’s the furthest along in the rebuild process, you want to step up and take a look inside?…Sure.”

Bykowski is the director of engineering for the Niagara Frontier Transportation Authority in Buffalo. And he’s in charge of overseeing the renovation of the Authority’s twenty seven light rail cars. Bykowski says after a quarter century of harsh Buffalo winters, the city’s rail cars were showing their age.

“The older cars that are out in the system right now, there’s a fair amount of rust along the bottom of the vehicles.”

“What we have done is when we replaced the frame we also replaced approximately 18 inches with stainless steel, which is a corrosion proof material.”

So, not everything on the old cars is reused. Workers at the Gray Manufacturing Industries shop are stripping down the first two cars to their shells. They’ll put in new sidewalls, new windows and seats. New electronic signage and audio systems also will be installed. But Bykowski says there’s a lot being recycled too.

“You’re saving all the steel, a lot of wiring that would have to be replaced. You’re saving copper. You’re reusing parts that are there.”

Bigger components are saved too.

The trucks and wheels are being patched, polished and eventually reattached to the cars.The motors will be rehabbed and go back into service too.

But, to be honest, Buffalo’s transit authority didn’t decide to recycle its rail cars because it’s good for the environment. It’s just trying to save some money. You see, rehabbing the cars costs about a million dollars each. That’s a third of what new cars cost.

Dave Gray is president of GMI, the company renovating the cars. Gray says they’re rebuilding cars for the Chicago and Philadelphia transit systems too.

“Most transit authorities try to rebuild vehicles. They always reach their mid-life, which is what the NFTA’s vehicles [have] done, and it’s very cost effective, so refurbishing makes a lot of sense.”

Not every city has had to be so frugal. Recently, some cities received federal stimulus money for their light rail systems. And a few of them, such as San Francisco, Washington D.C. and Miami, are simply going out and buying a brand new fleet. It is a whole lot easier and faster. It’s going to take three years to refurbish all of the rail cars in Buffalo’s fleet. Larry Meckler heads Buffalo’s transit authority. Meckler says he certainly doesn’t blame other cities for scrapping their fleet.

“If there’s other jurisdictions that can pull it off and get new cars, I’d say get the new cars because it’s a lot of effort, a lot more work, a lot more engineering – but they cost less. So, obviously, if we had the money and life was great and this was a utopian situation, every time a car hit [the end of] its usefulness, I’d just go out and buy another one.”

Still, being fiscally responsible is paying off. The authority saved taxpayers a lot of money. And in the end, Buffalo’s refurbished cars will look and work as every bit as good as new ones. Plus, even if it was unintended, the transit authority’s decision to reduce, reuse and recycle does let it claim the moral high ground.

For The Environment Report, I’m Joyce Kryszak.

Related Links

Billions for Better Rail Service

  • High speed trains may be sprouting up across the country in light of the recent initiative. (Photo courtesy of Black Leon)

The U.S. government is spending billions of dollars to improve the nation’s railroads and passenger train service. But those billions will be just the beginning of the cost of updating rail service. Lester Graham reports:

Transcript

The U.S. government is spending billions of dollars to improve the nation’s railroads and passenger train service. But those billions will be just the beginning of the cost of updating rail service. Lester Graham reports:

New investments in higher-speed rail are making passenger rail supporters almost giddy. Eight billion dollars from the Recovery Act is seed money for new high-speed routes in California and Florida and improvements for existing routes in other regions.

At a recent National Press Club panel discussion, Amtrak’s Joseph McHugh said Amtrak is not getting any of that money… but it’ll improve the freight railroads on which Amtrak operates its trains.

McHugh: And that means higher speeds, reduced trip time, additional frequencies, improved facilities, and a higher level of reliability for our services all around the country.

Beyond that first eight-billion dollars, the Department of Transportation’s so-called TIGER grants mean a few billion dollars more for further upgrades railroads and depots that tie into commuter rail, light rail and other mass transit.

Supporters of rail are expecting big things from the investments.

But others see spending billions upon billions of dollars on passenger rail as wasted money. They don’t see the utopia of transportation in better, faster trains. Many online comments from readers of stories on higher-speed rail indicate they don’t want the government to subsidize rail projects. They see it as stealing from necessary highway and bridge improvements. Others are more political, saying the government is trying to imitate the high-speed rail of Europe when –they feel– Americans are more independent and prefer cars.

So the debate sometimes devolves into — car versus train. Or individuality versus socialism.

Susan Zielinksi heads up the Universtiy of Michigan’s SMART transit project. She says that’s the wrong way to view it.

Zielinski:I think we get ourselves stuck in the polarization and this isn’t about getting rid of cars.

She says better passenger rail and tying it in to better mass transit gives more people more choices. She notes not everyone has access to a reliable car.

Environmentalists add… the train is just more environmentally friendly. Howard Lerner is with the Environmental Law and Policy Center.

Lerner: On a per-passenger-mile basis, rail is about three times as efficient as travel by car in terms of fuel efficiency, six times as efficient as travel by air. So, there are pretty substantial pollution reduction benefits, both in terms of greenhouse gasses and other pollutants when it comes to traveling by rail.

But the investment of billions of dollars during the Obama administration is generally considered just the down payment on the cost of bringing U.S. passenger rail service into the 21st century. Just a couple of years ago the Bush administration tried to zero-out the Amtrak budget. A future president might do the same.

Susan Zielinksi at the University of Michigan believes the improvements in rail service we’ll see in just the next several years will prove this investment is worth it.

Zielinski: Congress is not going to be able to go backwards on this. This is going to usher in a whole new set of industry opportunities, of economic development in communities, of new opportunities for jobs.

But even people who like the idea of improved passenger rail service say if this doesn’t result in the trains arriving on time… doesn’t fix the problem of having no transportation once they arrive at the depot… doesn’t spiff up the drab Amtrak train cars… and keep train ticket prices reasonable… it’ll be hard not to keep piling into the car or cramming themselves into an airline seat.

For The Environment Report, I’m Lester Graham.

Related Links

High-Speed Rail Money Slow

  • Some states have shovel-ready rail projects, but others states are just in the planning stage. Here is a high-speed train in Taiwan. (Photo source: Jiang at Wikimedia Commons)

Today, August 24, is a deadline for
states competing for eight billion
dollars in federal stimulus money
for higher speed rail. Shawn Allee reports, this stimulus could
run in slow-motion:

Transcript

Today, August 24, is a deadline for
states competing for eight billion
dollars in federal stimulus money
for higher speed rail. Shawn Allee reports, this stimulus could
run in slow-motion:

Federal Railroad Administration staff are staying late tonight – August 24 – to accept hundreds of applications for higher-speed rail funds.

FRA spokesperson Rob Kulat says the agency wants to give out stimulus money quickly, but, just in case, it’s announced there might be two rounds of applications – not just one.

“It would be a delay, but the idea is to have successful projects, to have them work cost-effectively. If a state isn’t ready financially or technically to implement their plan, then they need to go back to the drawing board a bit. We’re not going to throw good money after bad.”

Kulat says some states have shovel-ready rail projects, but others states are just in the planning stage.

It could be years before they clear the track for faster trains.

For The Environment Report, I’m Shawn Allee.

Related Links

Seaway Toll to Hurt Shipping Business?

  • President Bush is proposing a toll for use of the St. Lawrence Seaway. Some worry the toll will dissuade usage and hurt businesses. (Photo courtesy of the Bureau of Transportation Statistics)

The Bush Administration wants to charge ships
for passing through the St. Lawrence Seaway. The
Seaway links the Great Lakes with the Atlantic Ocean.
The Administration hopes the toll will help the
system pay for itself. The Great Lakes Radio
Consortium’s David Sommerstein reports:

Transcript

The Bush Administration wants to charge ships for passing through the St. Lawrence Seaway. The Seaway links the Great Lakes with the Atlantic Ocean. The Administration hopes the toll will help the system pay for itself. The Great Lakes Radio Consortium’s David Sommerstein reports:


The Bush Administration’s spending plan for next fiscal year calls for
raising 8 million dollars through a new toll system on the Seaway. The
shipping industry says the move could hurt businesses and cost jobs. But
Seaway Administrator Albert Jacquez says he doesn’t expect tolls to affect
traffic levels. He says there used to be a toll, but it was eliminated in
1987.


“If you look at five years before we stopped collecting tolls and five years
after, you’ll see very little change in the level of cargo that moves
through the system, and so I wouldn’t expect a great impact.”


Jacquez says the state of the economy in North America has a much larger
effect on cargo than any other factor.


Great Lakes shippers say the plan is unfair because it would force them to
pay twice for using the Seaway – once for an existing harbor maintenance
tax, and again for a transit toll.


For the Great Lakes Radio Consortium, I’m David Sommerstein.

Related Links

Governments Grapple With Regional Transport

Many large cities throughout the Midwest have been struggling with issues such as urban sprawl. Getting workers from one area to the jobs in another has become a transportation challenge. Building multi-lane highways only seems to encourage more sprawl, so many cities have worked with surrounding suburbs to build mass transit systems for the entire metropolitan region. For one major city, political leaders are just now getting around to making that happen and as the Great Lakes Radio Consortium’s Jerome Vaughn reports… even now it’s not going to be easy:

Transcript

Many large cities throughout the Midwest have been struggling with
issues such as urban sprawl. Getting workers from one area to the jobs
in another has become a transportation challenge. Building multi-lane
highways only seems to encourage more sprawl. So many cities have worked
with surrounding suburbs to build mass transit systems for the entire
metropolitan region. For one major city, political leaders are just now
getting around to making that happen. And as the Great Lakes Radio
Consortium’s Jerome Vaughn reports… even now it’s not
going to be easy:


Detroit is the 10th largest city in the country…and it’s had more than
its share of struggles over issues such as chronic unemployment, poverty,
and pollution.


Finding solutions to those intractable problems has long been a goal of
government leaders in the area. But over the past three decades…they’ve lacked
one tool… used by most other metropolitan areas
around the country…that can make a difference. A regional transportation
system.


But that’s about to change.


Michigan Governor Jennifer Granholm has joined Detroit Mayor Kwame
Kilpatrick…and the heads of the three largest counties in Metro
Detroit…to announce the formation of the Detroit Area Regional
Transportation Authority…otherwise known as DARTA.


The new regional transportation authority is backed by local governments,
business interests ..and mass transit proponents. The government leaders have
signed an agreement to work towards the regional transportation
system. Detroit Mayor Kwame Kilpatrick says the new deal will benefit the
city AND suburbs.


“This is a real people thing today. It’s also an economic thing…and it’s
rare when these two things come together. This will drive the economic
engine of the state. To move people to jobs…leads to economic
independence.”


The agreement is the first step towards ending decades of debate over how
best to get workers from their homes to their jobs. With many Detroiters
living below the poverty level…owning a car is impossible. But that can
mean taking several buses over a span of three hours just to get to work
each day.


That type of commute is what DARTA proponents, like such as Attorney Richard
Bernstein hope to end. As a blind man…he’s unable to drive to get
where he needs to go. He says Detroit’s lack of coordinated mass
transportation pushed him to become a transit activist a couple of years
ago.


“As a disabled person who can’t drive…I struggle for my independence and I
struggle for my freedom. And DARTA is the only hope that someone like me
has in order to lead a quality of life here in Southeast Michigan.”


Bernstein says he’d like to have that extra measure of independence. But he
says…right now…it’s impossible for him to get around town on his
own…given the current state of mass transit in Metro Detroit.


“For me right now …it isn’t that regional transit is difficult to
use…it’s that it’s non existent …that is the issue. Ultimately, if I want
to get from my house …or my apartment to my office. There is no bus I can
take. There is no bus I can take from my office to court.”


But Bernstein’s passion for regional transportation isn’t uniformly shared.
The original measure creating DARTA was vetoed by former Governor John
Engler last year as one of his final acts in office. The state legislature
tried to resurrect the bill in January…but it has subsequently
stalled…pushing the new governor, Jennifer Granholm and Detroit Mayor Kwame
Kilpatrick and others to find alternate ways routes to create a working agreement.


The opponents say the regional transportation system is not fair. State
Representative Leon Drolet opposes DARTA because he says his more rural
constituents shouldn’t be taxed for a bus system they’ll never use. He wants a
provision that would let communities “opt-out” of the DARTA if they choose. The
Republican legislator says he also concerned because there’s no plan to pay for
DARTA yet. And he says no one’s convinced him that such a system is really
needed in Metro Detroit…home of the Big Three automakers..


“Macomb, Oakland suburban Wayne communities…those are built around the
car. Everywhere there’s a parking lot. Boston, Washington DC, New
York…those communities…mass transit is very viable in the inner areas
because it costs 30 bucks a day or 50 bucks a day to park your car. And
that’s what drives people to mass transit…the inconvenience of driving
your car.”


But automakers say they want the regional mass transit system. The
Southeastern Michigan Council of Government’s Transportation
Expert…Carmine Palombo…says many of the region’s businesses are having a
hard time getting workers from their homes to their jobs. And that includes
the Big Three automakers…who have come out in favor of DARTA.


“The auto company themselves employ people who need to have good transit in
order to get to their jobs…and so they’re feeling the pinch…just like
every other employer is who wants to get…make sure they get to the jobs
they have to offer in a stable environment. So the car companies aren’t the
problem.”


(sound up – bus)


While the Detroit Area Regional Transportation Authority agreement has been
signed….the work is just beginning for transit activists in
Metro-Detroit. The current agreement only provides for planning a
regional transportation system. There’s currently no money for
implementation of ANY plan.


And DARTA opponents such as Leon Drolet are still on the job, too. He’s
charging that the chairman of his county…had no authority to sign
the DARTA agreement…and is asking the State’s Attorney
General to investigate.


For the Great Lakes Radio Consortium, I’m Jerome Vaughn.